Skip to main content
main-content

01.12.2015 | Case report | Ausgabe 1/2015 Open Access

BMC Musculoskeletal Disorders 1/2015

Successful treatment of a fracture of a huge Achilles tendon ossification with autologous hamstring tendon graft and gastrocnemius fascia flap: a case report

Zeitschrift:
BMC Musculoskeletal Disorders > Ausgabe 1/2015
Autoren:
Hisatoshi Ishikura, Naoshi Fukui, Hiroshi Takamure, Satoru Ohashi, Mitsuyasu Iwasawa, Kentaro Takagi, Ayako Horita, Ikuo Saito, Toshihito Mori
Wichtige Hinweise

Competing interests

The authors declare that they have no competing interests.

Authors’ contributions

NF drafted the manuscript and critically revised it for important intellectual content. HT and KT performed the surgical procedures and critically revised the manuscript for important intellectual content. AH and IS performed histological examinations of the excised specimens and critically revised the manuscript for important intellectual content. SO, MI, and TM provided advice and guidance regarding the surgical procedure and critically revised the manuscript for important intellectual content. All authors read and approved the final manuscript.

Authors’ information

NF is a professor in the Department of Life Sciences at the Graduate School of Arts and Sciences of the University of Tokyo.
Abbreviations
AOFAS
American Orthopedic Foot and Ankle Society
ATRS
Achilles tendon total rupture score
FOAT
fracture of ossified Achilles tendon
GC
gastrocnemius
ROM
range of motion

Background

Ossification of an Achilles tendon is a rare entity. Furthermore, only a few cases of fracture of an ossified Achilles tendon (FOAT) have been reported [ 17]. In previous reports, FOAT was treated either conservatively or surgically by excision and reconstruction using gastrocnemius (GC) fascia flaps, tensor fascia latae grafts, or adjacent tendons. However, to date, no standard treatment methods have been established for FOAT. In addition, currently available methods may not be effective in treating extensive ossifications, which would leave large defects after excision. We report the case of a fracture of a huge Achilles tendon ossification that was successfully treated by ossification removal and tendon reconstruction with an autologous hamstring tendon graft and GC fascia flap. Our novel surgical procedure for FOAT showed promising short-term results. To the best of our knowledge, this is the first report to describe the use of a hamstring tendon graft for reconstruction of FOAT.

Case presentation

Case report

A 50-year-old woman (height 155 cm, weight 54 kg) with right hindfoot pain was referred to our clinic in April 2014. She had experienced discomfort in her right hindfoot over the last several years. The discomfort had gradually worsened over the past several months. She was working as a full-time bank employee, and hindfoot pain on standing and walking was making her train commute to work difficult. She had no significant medical, family, or psychosocial history. Ankle range of motion (ROM) was limited to 10° for dorsal flexion and 40° for plantar flexion. Physical examination revealed diffuse ankle swelling, Achilles tendon stiffness, and moderate tenderness to palpation. Despite this discomfort, she could walk stably without a limp and stand on her tiptoes. Radiographs revealed extensive Achilles tendon ossification and osteoarthritis of the ankle joint (Fig.  1a, b). The length of the ossification was approximately 14 cm. She was prescribed oral anti-inflammatory agents. Ten days later, she felt a sudden pain in her right hindfoot while going up the stairs. The pain progressively worsened, causing her to limp. She visited our clinic several days after the incident. Ankle ROM was reduced to −5° for dorsal flexion and 30° for plantar flexion. Palpation revealed a severely tender defect 5 cm proximal to the Achilles tendon insertion. She could not stand on her right tiptoe and had a positive Thompson test. A radiograph of her right Achilles tendon showed a gap within the ossified mass, indicating FOAT (Fig.  2a). Sagittal proton density and T2-weighted magnetic resonance imaging demonstrated a high signal intensity line at the fracture site (Fig.  2b). The MRI also indicated that her gastrocnemius and soleus muscles were rather well preserved. Blood and radiological tests were performed to rule out the presence of systemic disease, and no abnormalities were detected.
Surgery was performed with the patient in the prone position. A longitudinal midline skin incision was made directly above the Achilles tendon to expose the bony mass. The fracture site was 5 cm proximal to the tendon insertion. The proximal part of the ossified tendon, which was 9.3 cm in length, was excised en bloc. The distal part was removed with several blocks (Fig.  3). The defect was 12 cm in length, even with the ankle in maximal plantar flexion.
After ossification removal, the hamstring tendons were obtained for reconstruction of the Achilles tendon. A 4-cm oblique incision was made over the pes anserinus, and the ipsilateral semitendinosus and gracilis tendons were harvested proximally using an open-ended tendon stripper while the knee was held at 30° of flexion to reduce the tension on the tendons. The tendons were then freed distally at the tibial insertion. Both tendons were approximately 20 cm long. After removing muscle tissues attached to the tendons, the tendons were bundled together, and the proximal part of the hamstring tendon graft was tied using a baseball suture technique with 1–0 threads. The ends of these threads were passed through the GC fascia and then sutured to the proximal Achilles tendon stump (Fig.  4a). The distal part of the graft was passed through a small incision in the substance of the distal Achilles tendon stump in a medial to lateral direction and then overturned proximally. With the ankle in maximal plantar flexion, the graft was sutured to the stump at the entry and exit points. As the plantaris tendon remained intact, the proximal part of this tendon was harvested with a tendon stripper and folded in half to reinforce the reconstruction. Finally, the proximal part of the graft was reinforced by turning the GC fascia flap downwards (Fig.  4b).
Postoperatively, the involved ankle was immobilized for 4 weeks in a below-knee non-weight-bearing cast with approximately 20° of plantar flexion. After removing the cast, she was instructed to wear a hinged ankle-foot orthosis that permitted full plantar flexion but limited dorsiflexion to a set angle [ 8], and to perform active ROM exercises. At week 7, full weight-bearing with the orthosis was permitted, and passive dorsiflexion exercises were initiated. At week 10, the orthosis was removed, and ROM exercises and gait training were continued. ROM exercises and gait training were performed under the supervision of the same experienced physical therapist. No adverse events occurred during the postoperative period.
One year after the operation, she had little pain and discomfort in the right Achilles region and was able to stand on her right tiptoe. Ankle ROM for dorsiflexion and plantar flexion was 15° and 45°, respectively, which was almost the same as that of the contralateral side. The American Orthopedic Foot and Ankle Society (AOFAS) Ankle/Hindfoot Scale score [ 9] and Achilles tendon total rupture score (ATRS) were used to evaluate preoperative and postoperative clinical status [ 10]. One year after surgery, the AOFAS score and ATRS increased from 50 to 75 and 23 to 56, respectively. Further improvements in these scores were limited by anterior ankle pain that remained after surgery, which was attributed to osteoarthritis of the ankle joint.
Histologically, the ossified tendon showed a mixture of fibrous tissue, cartilaginous tissue, and lamellar bone with little inflammatory cell infiltration. These findings indicated that part of the collagenous fiber of the tendon underwent cartilaginous metaplasia and was gradually replaced by lamellar bone (Fig.  5a, b). The lamellar bones were surrounded by many osteoblasts, suggesting endochondral ossification of the Achilles tendon.

Discussion

Achilles tendon ossifications are rare and usually asymptomatic, particularly those that are small and localized. Although the exact mechanism of ossification is unknown, the most common proposed etiologies are previous surgery and trauma [ 13, 1115]. Infectious, metabolic, and systemic diseases such as syphilis, GC abscess, gout, diabetes, Wilson’s disease, ochronosis, diffuse idiopathic skeletal hyperostosis, Reiter’s syndrome, and ankylosing spondylitis may also cause ossification [ 14, 11, 14]. In our case, none of these diseases was present, and the laboratory data were unremarkable. The only cause applicable to our patient was previous trauma. The patient had sustained a right ankle dislocation, which was repositioned manually, and a partial rupture of the right Achilles tendon while playing high school basketball (Table  1). She did not undergo surgery or improper conservative treatment (e.g., prolonged cast immobilization) for these injuries. Therefore, the Achilles tendon ossification and osteoarthritis of the ankle joint were likely due to injury-related trauma and not treatment-related trauma.
Table 1
Timeline
1980
Dislocation of the right ankle Partial rupture of the right hindfoot
2008
Discomfort in the right hindfoot
2014.4
Achilles tendon ossification
Osteoarthritis of the ankle joint
2014.4
Oral anti-inflammatory drugs
2014.4
Fracture of ossified Achilles tendon
2014.5
Ossification removal and reconstruction using autogous hamstring graft and gastrocnemius fascia flap
2015.5
Little pain or discomfort in the right Achilles region
Mild anterior ankle pain due to osteoarthritis of the ankle joint
Only a few cases of FOAT have been previously reported. No standard treatments for FOAT have been established, and the optimal treatment for this condition remains a matter of debate; however, both conservative and surgical treatments have been proposed. Goyal et al. reported that conservative treatment of FOAT produced a satisfactory functional result in an 84-year-old man [ 3]. However, given the younger age and higher activity level of our patient, a conservative approach was not likely to produce the desired functional outcome. Resnik et al. reported a case of 36-year-old man who underwent conservative treatment for FOAT. The patient experienced persistent pain and swelling and eventually underwent surgical excision of the bony mass and tendon reconstruction [ 5]. Several other reports have also recommended surgical treatment of FOAT [ 1, 6, 13], including internal fixation of the fractured mass [ 16] and surgical excision and reconstruction using GC fascia flaps [ 4, 11, 17] or tensor fascia latae grafts [ 5]. FOAT may also be treated by an adjacent tendon transfer; the use of the flexor hallucis longus tendon and a peroneus brevis tendon has been reported [ 7, 18].
The current case is unique in the longer length of the ossification compared with previously reported cases. Thus, previous reconstruction methods would not have been sufficient to repair the large gap remaining after excision of the mass. Meanwhile, fixation of the fractured mass may not be the treatment of choice because of the risks of fracture non-union and refracture. To determine the appropriate tissues to use for the reconstruction, we referred to previous reports of chronic Achilles tendon ruptures. Semitendinosus and gracilis tendons have both been used for the reconstruction of large defects caused by chronic Achilles tendon ruptures and have yielded good clinical and functional results [ 1922]. Considering this and the patient’s activity level, we initially planned to reconstruct the Achilles tendon using the double-folded semitendinosus and gracilis tendons. Although good results have been reported with tendon transfer techniques [ 7, 18], we did not consider those methods because connecting the proximal and distal stump firmly using a free tendon graft may better restore continuity and muscle function and strength compared to tendon transfer. We propose that free tendon grafting is a more suitable surgery to address the large gap in FOAT; however, the method may have several drawbacks, such as the need for another incision and the complexity of the surgical procedure, which may thus increase the risk of complications.
During surgery, we found that the defect in the tendon was too large to be reconstructed by double-folded tendons. Thus, the hamstring tendons were grafted as single bands, and a GC fascia flap and a plantaris tendon were added to augment it [ 19, 23]. The use of multiple tissues provided sufficient strength to the reconstructed tendon. This is the primary advantage of our procedure, which likely contributed to the satisfactory result in our patient. Since a chronically disrupted Achilles tendon has been successfully reconstructed with a semitendinosus or gracilis tendon alone [ 1923], there may be concern that the reconstructed tendon might have been over-augmented in our procedure. Admitting this possibility, we still believe that our method is a viable option for Achilles tendon reconstruction, especially when the gap is extremely large and the patient is young and active.
In the present patient, the distal part of the Achilles tendon was not ossified, which allowed us to stably fix the graft to the tendon stump distally. However, if the distal end of the Achilles tendon was affected and required excision, it would be an issue as to how the graft was to be fixed to the calcaneus. A recent study has shown that the calcaneal insertion may be successfully reconstructed with the use of an interferential screw [ 22].
In the present case, the ossified mass did not exhibit a unique histology despite its exceptional size. Previous studies have shown that Achilles tendon ossifications exhibit a variety of histological findings, including endochondral and intramembranous ossification, lamellar bone, and conglomerate foci of calcification [ 24]. However, to date, cartilaginous metaplasia of fibroblasts and subsequent endochondral ossification is the most accepted hypothesis for the pathogenesis of Achilles tendon ossifications [ 11]. The histological findings in our case are consistent with this hypothesis. Therefore, the large size of the ossification in our case may not be related to the etiological cause. We speculate that the lack of treatment of the initial traumatic injuries may be responsible for the extensive ossification.

Conclusion

We describe the case of a fracture of an extensive Achilles tendon ossification that was successfully repaired using a novel tendon reconstruction method consisting of a combination of autologous hamstring tendon graft and GC fascia flap. This reconstruction method may be used for treating not only FOAT but also large Achilles tendon defects due to trauma, malignancy, or other causes.

Consent

Written informed consent was obtained from the patient for publication of this case report and any accompanying images. A copy of the written consent is available for review by the Editor of this journal.

Acknowledgements

We thank Shuji Taketomi, M.D., Ph.D. for his valuable advice regarding the surgical procedure. We also thank Ryushi Marutani, M.D., Tatsuo Ikenaka, M.D., and Tomoko Jin, R.P.T. for their dedicated support in the postsurgical rehabilitation.
None of the authors has received any funding related to this manuscript.
Open AccessThis article is distributed under the terms of the Creative Commons Attribution 4.0 International License ( http://​creativecommons.​org/​licenses/​by/​4.​0/​), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver ( http://​creativecommons.​org/​publicdomain/​zero/​1.​0/​) applies to the data made available in this article, unless otherwise stated.

Competing interests

The authors declare that they have no competing interests.

Authors’ contributions

NF drafted the manuscript and critically revised it for important intellectual content. HT and KT performed the surgical procedures and critically revised the manuscript for important intellectual content. AH and IS performed histological examinations of the excised specimens and critically revised the manuscript for important intellectual content. SO, MI, and TM provided advice and guidance regarding the surgical procedure and critically revised the manuscript for important intellectual content. All authors read and approved the final manuscript.

Authors’ information

NF is a professor in the Department of Life Sciences at the Graduate School of Arts and Sciences of the University of Tokyo.
Literatur
Über diesen Artikel

Weitere Artikel der Ausgabe 1/2015

BMC Musculoskeletal Disorders 1/2015 Zur Ausgabe

Arthropedia

Arthropedia

Grundlagenwissen der Arthroskopie und Gelenkchirurgie. Erweitert durch Fallbeispiele, DICOM-Daten, Videos und Abbildungen. » Jetzt entdecken

Neu im Fachgebiet Orthopädie und Unfallchirurgie

Mail Icon II Newsletter

Bestellen Sie unseren kostenlosen Newsletter Update Orthopädie und Unfallchirurgie und bleiben Sie gut informiert – ganz bequem per eMail.

Bildnachweise