Eradication rates, risk factors, and implant selection in two-stage revision knee arthroplasty: a mid-term follow-up study

Several studies have identified comorbidities and conditions that increase the rate of periprosthetic joint infection (PJI) after primary hip and knee arthroplasty [1‐8]. In two-stage revision (TSR) surgery, protocols involving the implantation of an antibiotic-loaded bone–cement spacer have become the gold standard for treating periprosthetic infections.

Radical debridement with explantation of the prosthesis and supportive administration of antibiotics are the most important pillars for controlling PJI [9, 10], but reinfection rates after TSR continue to be high. Reinfection rates reported in the literature range from 4 to 50 % [3, 4, 11‐16]. Only a few studies have analyzed the factors that have a negative impact on infection control after TSR [17‐20]. In order to minimize failure rates in TSR, evaluated treatment protocols and diagnostic algorithms are needed, and it should be possible to identify patients who are at higher risk of failure. Once risk factors have been identified, further investigations and additional treatments can help reduce failure rates.

The aim of the present study was to investigate the extent to which infection can be successfully controlled after two-stage revision knee arthroplasty and identify factors that influence the failure rate.

Seventy patients who underwent two-stage revision knee arthroplasty between 2004 and 2008 in our department were identified. The following criteria were used to define PJI: sinus tract communicating with the prosthesis and/or at least two identical positive cultures identified intraoperatively [21, 22]. All infections were defined as delayed or late chronic [23].

Seven patients had died and four patients declined to participate in the study, and a total of 59 patients were therefore included. Their average age at follow-up was 73 years (±9.7), and there were 32 men and 27 women. The patients were all referred to our institution as a tertiary center. The protocol consisted of explantation of the prosthesis with implantation of a fixed antibiotic-loaded bone–cement spacer (Refobacin® Revision bone cement; Biomet Inc., Warsaw, Indiana, USA; 1 g gentamicin and 1 g clindamycin/40 g cement) and at least 14 days of intravenous antibiotic administration, followed by at least 4 weeks of antibiotics orally. If necessary, additional antibiotics were mixed into the spacer, depending on the microbiological results, as an off-label application. All antibiotic treatments were administered in collaboration with the hospital’s Institute of Microbiology. After an interval of 14 days without antibiotics, C-reactive protein (CRP) was measured in serum. The second-stage procedure was performed 9–12 weeks after explantation.

The criteria for reimplantation were no sinus track, no signs of local inflammation, and serum CRP values that had declined during the period since explantation. The definition of infection control was no subsequent surgical intervention for infection at the time of follow-up. Eleven potential risk factors were documented from the demographic data, comorbidities, and postoperative complications.

The amputation rate when infection could not be controlled was 6.8 % (4/59); amputations were required in one patient with an arthrodesis and three with revision endoprostheses. Figure 1 shows the clinical course for all of the patients. The risk factors investigated and the results of the univariate logistic regression are listed in Table 1. Although patients who had Staphylococcus epidermidis at the first revision had the highest failure rate (35.3 %), statistical analysis was not performed due to the small number of cases. Table 2 presents the results of the multivariate logistic regression analysis after variable selection. Table 3 shows the organisms that were cultured in patients with recurrent infections and the choice of implant. Identical bacteria were found at the second TSR in eight of the 17 patients concerned (47.1 %).

Periprosthetic joint infection (PJI) is one of the most severe complications that occur in patients who undergo total knee arthroplasty (TKA). Two-stage revision is still the gold standard for treatment of PJI, although one-stage revisions may achieve similar results in special conditions [24‐28]. Nevertheless, reinfection rates vary from 4 to 50 % [3, 4, 11‐16]. Among the patients included in the present study, successful treatment was achieved in 55 (93.2 %) after a mean follow-up period of 4.1 years.

There were no differences in the success rates between patients who underwent one TSR procedure and those with two procedures. Lower eradication rates have been reported in the literature after a second TSR [29], but a high rate of arthrodesis in the second TSRs might be an explanation for this. Isiklar et al. recommended arthrodesis instead of multiple revisions in patients with chronic infections, in order to avoid amputation [15].

Other studies have also reported higher rates of infection control with arthrodesis in comparison with revision prostheses [2, 11, 16, 30]. In contrast to these results, a 50 % failure rate after septic arthrodesis was reported in 2015 [31].

In view of the small numbers of arthrodeses, statistical analysis was not carried out in the present study and no conclusions can therefore be drawn on whether or not arthrodesis is in fact associated with lower reinfection rates.

It has to be discussed if allograft reconstruction of the extensor mechanism is an alternative instead of arthrodesis. Although it is known that allograft reconstructions show high rates of complications the benefit of a better mobility must be considered. In a study from 2016 in 26 knees, 69 % of the allografts could be retained at a follow-up of 68 months with a reoperation rate of 58 % [32, 33].

However, it is not only the type of treatment administered that is responsible for the clinical outcome. It is known from several studies that comorbidities and other conditions can have a negative influence on infection rates after primary arthroplasty [1‐8]. The causes of failure after TSR are rarely reported [17‐20].

The most frequent potential risk factors for failure were analyzed in the patients included in the present study. Among the comorbid conditions present, diabetes was identified as a risk factor, with an OR of 6.65 (95 % CI, 1.62 to 27.30) in the univariate analysis. Another study published in 2015 also found that diabetes had a significantly higher prevalence in the group with reinfections [19]. By contrast, Sakellariou et al. did not find any significant differences in a univariate analysis of 110 patients with TSR [18]. Among the local conditions that were present, fistulas were found to be a relevant factor in the univariate analysis. This finding is supported by a study also published in 2015, in which fistulas were associated with recurrent infection even in the multivariate logistic regression analysis [20].

A medical history including periprosthetic fracture around the knee was identified as a risk factor for failure after the first TSR. In an earlier study, our group showed that septic failure of revision arthroplasty with megaprostheses was strongly associated with a medical history of periprosthetic fractures around the knee [13].

Suzuki et al. investigated the influence of surgical procedures in the region of the knee joint. They observed significantly more frequent infections with open reduction and internal fixation after trauma to the knee joint and when osteosynthesis material remained in situ [7].

Two risk factors were identified in the multivariate logistic regression analysis in the present study: body mass index (BMI) and smoking. An increase in the BMI by one point showed an increased risk for failure of about 22 %. However, Mortazavi et al. did not observe any association between BMI and persistent PJI after two-stage TKA [25]. Kubista et al. distinguished between BMI scores of <25, 25–35, and >35.

No significant differences were observed between these groups with regard to the rates of persistent infection after two-stage TKA [34]. In a matched-cohort study, patients with a BMI >40 kg/m² had a 22 % risk for reinfection in comparison with patients with a BMI <30 kg/m², at 4 % [35]. In two-stage revision hip arthroplasty, obesity has also been found to be a significant risk factor for failure [36]. Higher rates of recurrent infection have also been reported among smokers, with a 71.4 % rate of persistent or recurrent infection after the first two-stage replacement in comparison with only 23.1 % in nonsmokers [6, 7, 37]. These results were confirmed in the present cohort.

The study has several limitations. As all of the patients were referred to the department, it was not possible to record all relevant factors. For example, the number of previous revision procedures was unclear and could not be analyzed, although it is known that this factor has a negative influence on complication rates [13, 17]. Due to the relatively small number of patients who underwent arthrodesis, statistical analysis was not useful. The wide variety of bacteria identified also made it impossible to carry out statistical analysis.

Two-stage revision (TSR) protocols can achieve acceptable results even when they are repeated. Amputation rates can be kept low. It is still unclear whether the choice of implant has an influence on failure rates. Risk factors for failure after two-stage revision have been identified, but studies with larger numbers of patients are needed in order to support these findings and identify further risk factors. In order to reduce failure rates, programs should be established for treating or minimizing risk factors in patients with periprosthetic joint infection.